Synthetic LPS-Binding Polymer Nanoparticles

Lipopolysaccharide (LPS), one of the principal components of most gram-negative bacteria's outer membrane, is a type of contaminant that can be frequently found in recombinant DNA products. Because of its strong and even lethal biological effects, selective LPS removal from bioproducts solution is of particular importance in the pharmaceutical and health care industries. In this thesis, for the first time, a proof-of-concept study on preparing LPS-binding hydrogel-like NPs through facile one-step free-radical polymerization was presented. With the incorporation of various hydrophobic (TBAm), cationic (APM, GUA) monomers and cross-linkers (BIS, PEG), a small library of NPs was constructed. Their FITC-LPS binding behaviors were investigated and compared with those of commercially available LPS-binding products. Moreover, the LPS binding selectivity of the NPs was also explored by studying the NPs-BSA interactions.;The results showed that all NPs obtained generally presented higher FITC-LPS binding capacity in lower ionic strength buffer than higher ionic strength. However, unlike commercial poly-lysine cellulose and polymyxin B agarose beads' nearly linear increase of FITC-LPS binding with particle concentration, NPs exhibited serious aggregation and the binding quickly saturated or even decreased at high particle concentration.;Among various types of NPs, higher FITC-LPS binding capacity was observed for those containing more hydrophobic monomers (TBAm). However, surprisingly, more cationic NPs with higher content of APM exhibited decreased FITC-LPS binding in high ionic strength conditions. Additionally, when new cationic monomer and cross-linker, GUA and PEG, were applied to replace APM and BIS, the obtained NPs showed improved FITC-LPS binding capacity at low NP concentration. But compared with APM- and BIS-containing NPs, the FITC-LPS binding capacity of GUA- and PEG-containing NPs saturated earlier.;To investigate the NPs' binding to proteins, we tested the NPs-bovine serum albumin (BSA) binding, which showed that, different from NPs FITC-LPS interactions, variation of TBAm's content in NPs had very little influence on BSA binding, instead, more cationic NPs with higher content of APM were found to possess higher BSA binding. Additionally, GUA-containing NPs exhibited particularly high BSA binding capacity, especially under low ionic strength conditions.;In the current formulations, the aggregation and saturation effects make NPs unsuitable in practical applications. Nevertheless, we anticipate that by attaching NPs onto certain substrates, particles may be effectively separated from each other, and the NPs' LPS binding capacity could potentially be further improved.